5mm LED CBI(R) Circuit Board Indicator Top View, Single 5.84 [.230] A 6.10 [.240] PART NO. 3.68 [.145] 2.54 [.100] B RECOMMENDED P.C. HOLE 2.54 PATTERN [.100] 2.54 [.100] COLOR GENERAL PURPOSE 6.10 [.240] 2.54 [.100] 550-xx04 CATHODE Red Cathode for Red/Green Bi-Color Yellow Cathode for Yellow/Green Bi-Color CATHODE 2.54 [.100] 550-0204 550-0304 550-0404 INTEGRAL RESISTOR 550-0504 550-0704 550-0804 A 3.43 [.135] for -0204 to -0404, 5.0 [.197] for all others B .635 [.025] for -0504 to -0704, .508 [.020] for all others LOW CURRENT Hole diameter: 1.22 [.048] for .635 [.025], 1.02 [.040] for all others 550-1104 550-1204 550-1304 Dimensions in mm [inches] Standard Polarity shown in drawing: Cathode same side as notch Features * Multiple CBIs form horizontal LED arrays on 6.35mm (0.250") center-lines. * High Contrast, UL 94 V-0 rated, black housing * Oxygen index: 32% * Polymer content: PBT, 0.160 g * Housing stand-offs facilitate PCB cleaning Red, 5V Green, 5V Yellow, 5V Red Yellow Green HIGH EFFICIENCY 550-2204 550-2304 550-2404 550-2504 Green Yellow Red Orange BI-COLOR 550-3004 550-3104 SUPER BRIGHT, DIFFUSED * Solderability per MIL-STD-202F, method 208F 550-5104 * LEDs are safe for direct viewing per IEC 825-1, EN-60825-1 550-5204 * Compatible with: 550-5304 550-xx04-004 quad block Green Yellow Red Red/Green Yellow/Green NEW Red Green Yellow 6 SUPER BRIGHT, WATER CLEAR (Non-tinted, Non-diffused) Custom * For custom LEDs contact factory. Tolerance note: As noted, otherwise: * LED Protrusion: 0.04 mm [0.016] * CBI Housing: 0.02mm[0.008] 550-5504 550-5604 550-5704 Red Green Yellow To order any of the 550-xx04 part numbers with Reverse Polarity (Cathode opposite side of notch), please add -010 to the part numbers shown above. PART NUMBER ORDERING CODE 5 5 0 - x x 0 4 - 0 1 0 Series LED Type Reverse Polarity Option 1) Cathode Opposite Side of notch -010 Ordering Code Suffix required ONLY for Reverse Polarity Option Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 6-9 550-xx04 Typical Operating Characteristics (TA=25C) GENERAL PURPOSE See LED data sheet for additional information See page 6-55 and 6-56 for Reference Only LED Drive Circuit Examples. See page 6-57 for Pin Out Part Number Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2 1/2 LED Data sheet Page # 550-0204 550-0304 Green Yellow 565 585 12.3 12.3 2.1 2.1 20 20 60 60 5ND-9674 5ND-9673 6-51 6-51 550-0404 Red 635 12.3 2 20 60 5ND-9672 6-51 INTEGRAL RESISTOR Part Number Color Peak Wavelength nm IV mcd Test Voltage Forward Current (mA) Viewing Angle 2 1/2 LED Data sheet Page # 550-0504 550-0704 550-0804 Red Green Yellow 655 565 583 2 8 8 5 5 5 13 12 10 60 60 60 5RD-9422 5RD-9423 521-9284 6-52 6-52 6-41 Part Number Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2 1/2 LED Data sheet Page # 550-1104 550-1204 550-1304 Red Yellow Green 635 583 565 2 1.8 1.8 1.8 1.9 1.8 2 2 2 50 50 50 521-9320 521-9321 521-9327 6-42 6-42 6-42 Page # LOW CURRENT HIGH EFFICIENCY Part Number Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2 1/2 LED Data sheet 550-2204 Green 563 10 2.1 10 65 5HD-9270-5 6-49 550-2304 550-2404 550-2504 Yellow Red Orange 585 650 600 6.3 7 7 2.1 2.2 1.9 10 10 10 50 50 60 5HD-9271-5 5HD-9269 521-9704 6-49 6-49 6-43 Part Number Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2 1/2 LED Data sheet Page # 550-3004 550-3104 Red/Green Yellow/Green 660/565 585/565 90/40 8.7/8.7 1.8/2.1 2.1/2.1 20 20 60 50 521-9651 521-9724 6-46 6-46 BI-COLOR SUPER BRIGHT, DIFFUSED Part Number Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2 1/2 LED Data sheet Page # 550-5104 550-5204 550-5304 Red Green Yellow 650 563 585 34 34 34 2.1 2.2 2.2 20 20 20 50 50 50 5SD-9441 5SD-9456 5SD-9455 6-53 6-53 6-53 SUPER BRIGHT, WATER CLEAR (NON-TINTED, NON-DIFFUSED) Part Number Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2 1/2 LED Data sheet Page # 550-5504 550-5604 550-5704 Red Green Yellow 635 565 583 125 120 140 2.2 2.3 2.2 20 20 20 24 24 24 521-9464 521-9465 521-9466 6-47 6-47 6-47 6-10 Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 5mm Discrete LED Integral Resistor, 5 Volts Diffused 9.19 [.362] 8.43 [.332] .76 [.030] 521-9183, -9284 PART NO. 521-9183 521-9284 5.84 [.230] .64 [.025] LED COLOR Red Yellow 2.54 [.100] 5.08 [.200] 4.57 [.180] 1.0 [.040] MAX 25.1 [1.00] MIN 1.27 [.050] 1.0 [.040] MAX CATHODE MOUNTING CLIP: 515-0004 located on page 6-48 Dimensions in mm [inches] Red Yellow ABSOLUTE MAXIMUM RATINGS (TA=25C) -9183 -9284 Forward Voltage (V) Derating (V/C) From 50C 7.5 .071 7.5 .071 Operating Temperature (C) -40/+85 -40/+85 Storage Temperature (C) -55/+100 -55/+100 Soldering Temperature 260C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Luminous Intensity (mcd) Min. VF = 5V Typical Red Yellow -9183 2 8 -9284 2 8 Peak Wavelength (nm) Peak Typical 635 583 Viewing Angle (2 1/2) Typical 60 60 Forward Current (I) VF = 5V Typical Max 10 15 10 15 Min. 5 5 Reverse Voltage (V), IR=100A 6 is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 6-41 5mm Discrete LED Low Current, 2mA Diffused 8.81 [.347] .76 [.030] 521-9320, -9321, -9327 PART NO. 521-9320 521-9321 521-9327 5.84 [.230] .46 [.018] 2.54 [.100] 4.83 [.190] 1.0 [.040] MAX 25.1 [1.00] MIN 1.27 [.050] 1.0 [.040] MAX COLOR Red Yellow Green CATHODE MOUNTING CLIP: 515-0004 located on page 6-48 Dimensions in mm [inches] Red Yellow Green -9320 -9321 -9327 Power Dssipation (mW) Derating (mA/C) From 92C 27 1 36 1 24 1 Forward Current (mA) 7 7 7 Peak Current (mA) Pulse width = 10 s 500 500 500 Operating Temperature (C) -55/+100 -55/+100 -55/+100 Storage Temperature (C) -55/+100 -55/+100 -55/+100 ABSOLUTE MAXIMUM RATINGS (TA=25C) Soldering Temperature 260C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Red Yellow Green -9320 -9321 -9327 Luminous Intensity (mcd) IF=2mA Min. Typical 1.2 2 1.2 1.8 1.2 1.8 Peak Wavelength (nm) Peak Typical 635 583 565 Viewing Angle (2 1/2) Typical 50 50 50 Forward Voltage (V) IF=2mA Typical Max. 1.8 2.2 1.9 2.7 1.8 2.2 Reverse Voltage (V), IR=50A Min. 5 5 5 is the off axis angle at which the luminous intensity is half the axial luminous intensity 6-42 Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 5mm Discrete LED Bi-Color Non-Tinted, Diffused 8.64[.340] 1.50 [.059] MAX 521-9651, -9724 5.59 [.220] 0.51 [.020] 5.00 [.197] 2.54 [.100] 22.1 [.87] MIN. 1.00 [.04] Dimensions in mm [inches] PART NO. LED COLOR 521-9651 Red/Green 521-9724 Yellow/Green CATHODE GREEN, RED/GREEN BI-COLOR 521-9651 CATHODE YELLOW, YELLOW/GREEN BI-COLOR 521-9724 MOUNTING CLIP: 515-0005 located on page 6-48 Red/Green Yellow/Green -9651 -9724 100/100 60/100 40/30 .5/.4 20/30 .25/.40 200/120 80/120 Operating Temperature (C) -55/+100 -55/+100 Storage Temperature (C) -55/+100 -55/+100 ABSOLUTE MAXIMUM RATINGS (TA=25C) Power Dissipation (mW) Forward Current (mA) Derating (mA/C) From 50C Peak Current (mA) Pulse width = 100 s Soldering Temperature 260C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Red/Green Yellow/Green -9651 -9724 Luminous Intensity (mcd) IF=20mA Min. Typical 29/12.6 90/40 2.5/2.5 8.7/8.7 Peak Wavelength (nm) Peak Typical 660/565 585/565 Viewing Angle (2 1/2) Typical 60 50 Forward Voltage (V) Typical 1.8/2.1 2.1/2.1 Max. 2.4/2.8 2.8/2.8 IF=20mA is the off axis angle at which the luminous intensity is half the axial luminous intensity 6-46 Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 5mm Discrete LED Super Bright, Water Clear Non-Tinted, Non-Diffused 8.81 [.347] 1.0 [.040] MAX 521-9464,-9465,-9466 5.84 [.230] 4.83 [.190] 2.54 [.100] 25.35 [.998] MIN 1.27 [.050] TYP CATHODE .46 [.018] SQ. Dimensions in mm [inches] ABSOLUTE MAXIMUM RATINGS (TA=25C) Power Dissipation (mW) Derating (mW/C) From 25C 1. From 50 C PART NO. COLOR 521-9464 521-9465 521-9466 Red Green Yellow MOUNTING CLIP: 515-0004 located on page 6-48 Red Green Yellow -9464 -9465 -9466 135 1.8 135 1.8 85 1.61 Forward Current (mA) 30 30 20 Peak Current (mA) Pulse width = 10 s 500 500 500 Operating Temperature (C) -55/+100 -20/+100 -55/+100 Storage Temperature (C) -55/+100 -55/+100 -55/+100 Soldering Temperature 260 C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Red Green Yellow -9464 -9465 -9466 Luminous Intensity (mcd) IF=20mA Min. Typical 80 125 80 120 80 140 Peak Wavelength (nm) Peak Typical 635 565 583 Viewing Angle (2 1/2) Typical 24 24 24 Forward Voltage (V) IF=20mA Typical Max. 2.2 3 2.3 3 2.2 3 Reverse Voltage (V), IR=100A Min. 5 5 5 is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 6-47 6 5mm High Efficiency Diffused 5HD-xxxx TYPE *5HD-9269 *5HD-9270-2 *5HD-9270-5 *5HD-9271-2 *5HD-9271-5 * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. ABSOLUTE MAXIMUM RATINGS (TA=25C) COLOR Red Green Green Yellow Yellow Red Green Green Yellow Yellow -9269 -9270-2 -9270-5 -9271-2 -9271-5 60 1 .66 140 75 1 .66 200 60 1 .66 Forward Current (mA) Derating (mA/C) From 25C 20 40 .6 25 60 .8 20 Peak Current (mA) 60 500 60 1000 60 Operating Temperature (C) -25/+85 -55/+100 -25/+85 -55/+100 -25/+85 Storage Temperature (C) -30/+100 -55/+100 -30/+100 -55/+100 -30/+100 Power Dissipation (mW) Derating (mW/C) From 50C 1. From 40C Pulse width = 1s Soldering Temperature 260C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Red Green Green Yellow Yellow -9269 -9270-2 -9270-5 -9271-2 -9271-5 Luminous Intensity (mcd) IF=10mA Min. Typical 2.2 7 4 32 3.6 10 4 10 2.2 6.3 Peak Wavelength (nm) Peak Typical 650 565 563 590 585 Viewing Angle (2 1/2) Typical 50 50 65 70 50 Forward Voltage (V) I F=10mA, *IF=20mA Typical Max. 2.2 2.5 2* 2.6* 2.1 3 2.4* 3* 2.1 3 Reverse Voltage (V), IR=100A *IR=10A Min. 5 5* 3* 5* 3 is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 6-49 6 5mm General Purpose Diffused 5ND-xxxx TYPE COLOR *5ND-9672 *5ND-9673 *5ND-9674 * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. Red Yellow Green Red Yellow Green -9672 -9673 -9674 Power Dissipation (mW) 80 60 100 Forward Current (mA) Derating (mA/C) From 25C 40 .5 20 .25 30 .4 Peak Current (mA) 200 80 120 Operating Temperature (C) -55/+100 -55/+100 -55/+100 Storage Temperature (C) -55/+100 -55/+100 -55/+100 ABSOLUTE MAXIMUM RATINGS (TA=25C) Pulse width = 10 s Soldering Temperature 260C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Red Yellow Green -9672 -9673 -9674 Luminous Intensity (mcd) IF=20mA Min. Typical 3.5 12.3 3.5 12.3 3.5 12.3 Peak Wavelength (nm) Peak Typical 635 585 565 Viewing Angle (2 1/2) Typical 60 60 60 Forward Voltage (V) IF=20mA Typical Max. 2 2.8 2.1 2.8 2.1 2.8 Reverse Voltage (V), IR=100A Min. 5 5 5 is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 6-51 6 5mm Integral Resistor Diffused 5RD-xxxx TYPE *5RD-9378 *5RD-9379 *5RD-9422 *5RD-9423 * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. ABSOLUTE MAXIMUM RATINGS (TA=25C) COLOR Green Yellow Red Green VOLTS 12 12 5 5 Green 12V Yellow 12V Red 5V Green 5V -9378 -9379 -9422 -9423 15* 15 7.5 7.5 Operating Temperature (C) -20/+85 -40/+85 -40/+85 -20/+85 Storage Temperature (C) -55/+100 -55/+100 -55/+100 -55/+100 Forward Voltage (V) *(TA=70C) Soldering Temperature 260C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Green 12V Yellow 12V Red 5V Green 5V -9378 -9379 -9422 -9423 Luminous Intensity (mcd) VF=5V, *VF=12V Min. Typical 1.5* 4* 1.5* 4* 1 2 2 8 Peak Wavelength (nm) Peak Typical 565 583 655 565 Viewing Angle (2 1/2) Typical 60 60 60 60 Forward Current (mA), VF=5V *VF=12V Typical Max. 13* 20* 13* 20* 13 20 12 15 Reverse Voltage (V), IR=100A Typical 5 5 5 5 is the off axis angle at which the luminous intensity is half the axial luminous intensity 6-52 Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com